2011 International 7400 recalls
The 2011 International 7400 is covered by 4 recall campaigns. Repairs are free at a dealer; check your VIN to see which are still open.
| Campaign | Received | Component |
|---|---|---|
| 14V186000 | 2014-04-08 | Electrical System › 12V/24V/48V Battery |
| 10V586000 | 2010-11-17 | Steering › Gear Box › Shaft Sector |
| 10V463000 | 2010-10-05 | Exterior Lighting › Headlights |
| 10V107000 | 2010-03-18 | Electrical System › 12V/24V/48V Battery |
Each recall: problem, risk and fix
Electrical System › 12V/24V/48V Battery (14V186000, 2014-04-08)
Problem: DUECO Inc. (DUECO), a manufacturer of utility vehicles, is recalling certain Dueco-modified model year 2009-2011 International 4300, 2010 International 4400, 2009 and 2011 International 7400, 2010 Freightliner M2, 2008-2009 GMC C5500, and 2011 Ford F-750 vehicles, equipped with Sure Power DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
Risk: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Free fix: DUECO will notify owners, and Sure Power will replace the converters, free of charge. The recall began on May 29, 2014. Owners may contact Dueco at 1-800-558-4004.
Steering › Gear Box › Shaft Sector (10V586000, 2010-11-17)
Problem: Navistar is recalling certain model year 2011 international 7300, 7400, and 7500 vehicles manufactured from june 30, 2010, through october 13, 2010. These vehicles were built with an incorrect steering system draglink.
Risk: Drivers may experience degraded steering feel and control, increasing the risk of a crash possibly resulting in property damage, personal injury, or death.
Free fix: Dealers will replace the steering draglink and pitman arm and will also inspect the steering arm for damage and replace if necessary. This service will be performed free of charge. All the affected vehicles have been repaired, therefore an owner notification letter will not be issued for this campaign. Owners may contact navistar at 1-800-448-7825.
Exterior Lighting › Headlights (10V463000, 2010-10-05)
Problem: Navistar is recalling certain model year 2011 international 7300, 7400, 7500, vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 108,Ds"'lamps, reflective devices, and associated equipment." These vehicles are installed with improper headlight height of 55.5 Inches and the correct height should be 54 inches.
Risk: Improper height on the headlights may not fully illuminate the road surface or may inhibit the ability of motorists to see vehicles which can increase the risk of a crash.
Free fix: Dealers will install the correct headlights free of charge. The safety recall is expected to begin on or before february 25, 2010. Owners may contact navistar at 1-800-448-7825.
Electrical System › 12V/24V/48V Battery (10V107000, 2010-03-18)
Problem: Navistar has notified nhtsa of a defect on certain model year 2008-2011 international trucks equipped with an optional jump start stud. Corrosion at the base of the stud may cause an electrical short between the stud and battery box.
Risk: An electrical short may cause a vehicle fire.
Free fix: A final remedy has been established. Navistar will notify owners, and dealers will repair the vehicles by installing a new jump start stud. Repairs will be preformed free of charge. An interim action will involve the removal of the jump start stud and the connecting cable. The safety recall began on september 10, 2010. Owners may contact international dealers at 1-800-448-7825.
Other model years: none with their own page · All International 7400 recalls